Study Of Tetraselmis sp. Biomass Production On Enriched Crumb Rubber Industrial Wastewater Media For Biodiesel Potential Biodisesel

Authors

  • Alumni Department of Agricultural Products Technology, Faculty of Agriculture, University of Lampung
  • Alumni Department of Agricultural Products Technology, Faculty of Agriculture, University of Lampung
  • Lecturer Department of Agricultural Products Technology Faculty of Agriculture University of Lampung

DOI:

https://doi.org/10.35450/jip.v4i01.7

Keywords:

nitrogen, sainity, wastewater, Tetraselmis sp.

Abstract

Tetraselmis sp. isone of the potential microalgae as a source of oil for biodiesel ingredient due to it produces large amount of biomass.  The purpose of this research was to determine the effectiveness of the nitrogen addition and salinity setting towards crumb rubber industrial wastewaterin increasing the production of Tetraselmis sp. biomass. This research was conducted by preparing four type of Tetraselmis sp. growth media that were crumb rubber industrial wastewater media of pond outlet Facultative I, Facultative II, Facultative II which was enriched by nitrogenat 1 g NH4HCO3/5 L of volumedose, and Facultative II whose salinity was enhanced up to 30 ppt.  The seed of Tetraselmis sp. as much as 25% v/v was cultivated in open pond bioreactor with 5 L of volume for 7 days.  The parameters in this research were daily cell density, biomass, N-total, P-PO4, Dissolve Oxygen (DO), pH, and salinity.The results showed that the enhance of salinity in crumb rubber industrial wastewater media from an outlet Facultative II pondup to 30 ppt was the most effective to increase production of Tetraselmissp. biomass as much as 105% with 120 x 104 cell/mL of cell density and0.6250 g/L of dry yield and also it was able to reduce 72,2% of N-total and 87,6% of P-PO4content.

Downloads

Download data is not yet available.

References

Amini, S. dan R. Susilowati. 2010. Produksi biodiesel dari mikroalga Batryococcus braunii. Squalen. 5 (1): 23-30.

Ayustama, A.L.S. dan E.A.W. Sari. 2010. Proses produksi mikroalga dalam photobioreaktor mini pond secara batch untuk bahan bakar biodiesel. Jurnal Teknik Kimia. 1: 1-6.

Balai Besar Pengembangan Budidaya Laut (BBPBL). 2007. Budidaya Fitoplankton & Zooplankton. Balai Besar Pengembangan Budidaya Laut. Lampung. 42 hlm.

Balai Budidaya Laut Lampung. 2002. Budidaya Fitoplankton dan Zooplankton. Balai Besar Pengembangan Budidaya Laut. Lampung.

Cahyaningsih, S dan A.N. Mei. 2006. Petunjuk Teknis Produksi Pakan Alami. Balai Benih Air Payau (BBAP).Situbondo.

Campbell, N.A. and J.B. Reece. 2002. Biologi Jilid 1 Edisi ke-5. Erlangga. Jakarta. 292 hlm.

Chisti, J. 2007. Biodiesel from microalgae. Biotechnology Advances. 25 (3): 294- 306.

Efendi, H. 2003. Telaah Kualitas Air bagi Pengelolaan Sumber Daya dan Lingkungan Perairan.Kaniasius.Yogyakarta.258 hlm.

Ernest, P. 2012. Pengaruh kandungan ion nitrat terhadap pertumbuhan Nannochloropsis sp. (Skripsi).Universitas Indonesia.Depok.83 hlm.

Febiana, V. 2015. Penggunaan aluminium sulfat sebagai flokulan pada pemanenan mikroalga Nannochloropsis sp. yang dikultivasi pada media limbah cair karet remah. (Skripsi). Universitas Lampung. Lampung. 65 hlm.

Ferriols, V.M.E.N. and R.O. Aguilar. 2012. Efficiency of various flocculants in harvesting the green microalgae Tetraselmis tetrahele (Clorodendrophyceae: Chlorodendraceae). International Journal of the Bioflux Society. 5 (4): 265-273.

Fogg, G.E. and B. Thake. 1987. Alga Cultures and Phytoplankton Ecology. The University of Wiconsin Press. London. 20 pp.

Goldman, C.R and A.J. Horne. 1983. Limnology. McGraw-Hill Book Company. Singapore. 464 pp.

Hadiyanto, I. Samidjan, A. C. Kumoro, dan Silviana. 2010. Produksi mikroalga berbiomasa tinggi dalam bioreaktor open pond. Prosiding Seminar NasionalTeknik Kimia. Universitas Diponegoro. Semarang. ISSN 1693- 4393.

Harimurti, I.P., D.D. Novrian, S.R. Juliastuti, dan N. Hendrianie. 2013. Pengaruh kadar nitrogen, CO2, dan salinitas terhadap peningkatan lipid pada Chlorella vulgaris dan Botryococcus braunii serta peran Chlorella vulgaris dan Botryococcus braunii dalam penurunan kadar COD pada limbah PT. SIER. Jurnal Sains dan Seni Pomits. 2 (1): 2337-3520.

Kawaroe, M., A. Rachmat, dan A, Haris. 2012. Optimalisasi seleksi spesies mikroalga potensial penghasil minyak mikroalga untuk menunjang kelayakan ekonomi produksi biodiesel. Prosiding InSINas. Institut Pertanian Bogor. Bogor. 7-11.

Komalasari, A. 2015.Studi penentuan jenis outlet limbah cair karet remah untuk pertumbuhan mikroalga dengan sistem open ponds.(Skripsi). Universitas Lampung. Lampung.62 hlm.

Mara D.D., S.W. Mills, H.W. Pearson, and G.P. Alabaster. 1992. Waste stabilization ponds: a viable alternative for small community treatment systems. J. Inst. Wat. Environ. Manag. 6 (1): 72-78.

Prabowo, D.A. 2009. Optimasi pengembangan media untuk pertumbuhan Chlorella sp. pada skala laboratorium.(Skripsi).Institut Pertanian Bogor. Bogor. 95 hlm.

Pulungan, A.D. 2012. Evaluasi pemberian dosis koagulan aluminium sulfat cair dan bubuk pada sistem dosis koagulan di instalasi pengolahan air minum PT. Krakatau Tirta Industri. (Skripsi). Institut Pertanian Bogor. Bogor. 76 hlm.

Utomo, T.P. dan E. Suroso. 2008. Optimasi produksi gas metana dari limbah cair industri karet alam menggunakan reaktor anaerobuk dua tahap dalam upaya penyediaan energi alternatif. (Laporan Penelitian). Universitas Lampung. Lampung. 29 hlm.

Utomo, T.P., U. Hasanudin, dan E. Suroso. 2012. Agroindustri Karet Indonesia. PT Sarana Tutorial Nurani Sejahtera. Bandung. 92 hlm Wardhana, W.A. 1994. Dampak Pencemaran Lingkungan. Andi Ofset. Yogyakarta. 459 hlm.

Wijanarko, A., K. Asami, and K. Ohtaguchi. The Kinetics of growth and the CO2 concentrating mechanism of the filamentous cyanobacterium Anabaena cylindrical in a bubble column. Journal of Chemical Engineering of Japan. 37: 1019-1025.

Wulan, R.R. 2015. Kemampuan mikroalga yang dikultivasi pada limbah cair industry karet remah dalam menghasilkan biomassa dan menurunkan cemaran.(Skripsi). Universitas Lampung. Lampung.60 hlm.

Published

2016-04-01

How to Cite

Otik, Tanto Pratondo, & Adriyanus Ivan. (2016). Study Of Tetraselmis sp. Biomass Production On Enriched Crumb Rubber Industrial Wastewater Media For Biodiesel Potential Biodisesel. Inovasi Pembangunan : Jurnal Kelitbangan, 4(01), 37-46. https://doi.org/10.35450/jip.v4i01.7

Issue

Vol. 4 No. 01 (2016): April 2016

Section

Articles

The Authors submitting a manuscript do so on the understanding that if accepted for publication, copyright of the article shell be assigned to Development Innovation: Jurnal Kelitbangan (JIP) , Balitbangda Provinsi Lampung as publisher of the journal.

Copyright encompasses exclusive rights to reproduce and deliver the article in all form and media, including reprints, photographs, microfilms and any other similar reproductions, as well as translations, the reproduction of any part of this journal, its storeage in databases and its transmission by any form or media. such as electronic, electrostatic and mechanical copies, photocopies, recordings, magnetic media, etc.